Automatic Power Factor Correction Panel

 Since 2004 We are the leading manufacturer of Automatic Power Factor Correction ( APFC ) Panels in Chennai, Tamilnadu, India. An automatic power factor correction unit is used to improve power factor. A power factor correction unit usually consists of a number of capacitors that are switched by means of contactors. These contactors are controlled by a regulator that measures power factor in an electrical network. To be able to measure power factor, the regulator uses a current transformer to measure the current in one phase.

• Depending on the load and power factor of the network, the power factor controller will switch the necessary blocks of capacitors in steps to make sure the power factor stays above a selected value (usually demanded by the energy supplier), Automatic Power Factor Capacitor in chennai, Tamilnadu, India. Power Factor Panel Mfrs in Chennai
• In view of constantly rising power tariff and the penalties charged by the State Electricity Board, it is incumbent for any HT / LT Consumer to install an apt APFC system for cut down the cost of Power Factor penalty and also to save Energy by consistently maintaining the higher Power Factor.
• The Low Power Factor leads to the poor efficiency, thereby increasing the apparent power drawn   (KVA) from the distribution network. This would reflects in overloading of Transformer, Bus bar Chamber, Switchgears, Cables & other distribution components within the consumers area.
• Low Power Factor leads to poor power efficiency there by increasing the apparent power drawn from the distribution network this results in overloading of Transformer, Cables & other distribution devices within the Industry or consumer area.  An apt power factor control system ensures optimum power for the running loads.

BENEFITS

• Avoids penalties for the Low Power Factor
• Reduction in the Maximum Demand (KVA)
• Reduction in the energy
• Claim higher Power Factor Incentives
• Longer life of the existing electrical distribution components
• Lower Electricity charge.

Ranges :

• LTCT 30 KVAr to 150 KVAr APFC Panel Manufactures in Chennai
• HT : 150 KVAr to 800 KVAr APFC Panel Manufactures in Chennai

Major Components :

• Capacitors :EPCOS from SIEMENS / L & T / Schneider / MOMAYA
• Power Factor Controllers : BELUK / EPCOS / MIKRO
• Switch Gears : L & T / SIEMENS / ABB / Schneider / CHINT